Product ID:757 THREAD JOINT COMPOUND
MSDS Date:01/01/1996
FSC:8040
NIIN:00F047766
MSDS Number: BZDJB

Emergency Phone: 407-844-0241

Info Phone: 407-844-0241

Preparer: N JOHNSON

Cage: FO174

Telephone: (407) 844-0241

Cage: FO174

NON-HAZARDOUS INGREDIENTS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: CAN CAUSE RESPIRATORY
IRRITATION. SKIN/EYES: CAN CAUSE SEVERE IRRITATION. POTENTIAL LOCAL
& SYSTEMATIC EFFECTS DUE TO REPEATED/LONG TERM EXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, TEARING, BLURRED VISION,
DEFATTING, DRYNESS, RASH, NAUSEA, VOMITING, HEADACHE, DIZZINESS,
STUPOR, DIARRHEA.

First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS.
INGESTION: IF CONSCIOUS, DILUTE BY GIVING 2 GLASSES OF WATER. KEEP
WARM & QUIET. DON'T INDUCE VOMITING. SKIN: FLUSH W/WATER.
INHALATION: REMOVE T O FRESH AIR. GIVE CPR IF NEEDED. OBTAINMEDICAL
ATTENTION IN ALL CASES.

Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE OPERATED IN
PRESSURE-DEMAND/OTHER POSITIVE PRESSURE MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:CONTAINS NFPA CLASS IIIB COMBUSTIBLE
LIQUID. SENSITIVITY TO IMPACT MAY PUNCTURE CONTAINER/LOOSEN CAP
CAUSING A LEAK.

Spill Release Procedures:EXTINGUISH & DON'T TURN ON ANY IGNITION SOURCE
UNTIL AREA IS TO BE FREE OF EXPLOSION/FIRE HAZARDS. ABSORB
W/SAND/INERT MATERIAL. DISPOSE OF AS SOLID WASTE.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
KEEP CONTAINER CLOSED. USE W/ADEQUATE VENTILATION.
Other Precautions:AVOID BREATHING VAPOR. AVOID CONTACT W/EYES, SKIN &
CLOTHING.

Respiratory Protection:IF THE TLV OF THE PRODUCT/COMPONENT ARE
EXCEEDED, A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED.
OSHA REGULATIONS ALSO PERMIT OTHER NIOSH/MSHA RESPIRATORS UNDER
SPECIFIED CONDITIONS.
Ventilation:IN A CONFINED AREA, SUFFICIENT MECHANICAL(GENERAL)&/LOCAL
EXHAUST TO MAINTAIN EXPOSURE < TLV. EXPLOSION-PROOF EQUIPMENT.
Protective Gloves:RUBBER/BUTYL/IMPERVIOUS
Eye Protection:CHEMICAL SAFETY SPLASH GLASSES
Other Protective Equipment:EYE BATH, SAFETY SHOWER, FACE SHIELD, RUBBER
SAFETY BOOTS.
Supplemental Safety and Health

Vapor Density:>1
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN BU AC
Appearance and Odor:LIGHT BLUE PASTE

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & OTHER SOURCES
OF IGNITION.
Hazardous Decomposition Products:TOXIC MATERIALS, CO2, CO & VARIOUS
HYDROCARBONS.

Waste Disposal Methods:MAY BE INCINERATED, ALLOW TO
EVAPORATE/SOLIDIFIED W/INERT MATERIAL & DISPOSE OF IAW/FEDERAL,
STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.